Model Perpindahan Massa pada Mikrofiltrasi untuk Penghilangan Limonin dan Naringin dari Jus Jeruk Siam (Citrus nobilis L. var microcarpa)

Abstract

Bitterness in citrus juice primarily due to the presence of limonin and naringin. Using membrane technology is expected to remove the bitterness. The decreasing of flux is a general membrane problem. Understanding of mass transfer mechanisms, the decreasing of membrane performance could be controlled. The research aimed to remove limonin and naringin from Siam citrus juice by microfiltration, to get the best condition of operation of microfiltration i.e. higher permeate flux and rejection, and to predict mass transfer mechanisms on the microfiltration for removing limonin and naringin from Siam citrus juice. Raw material of the study was Siam citrus. The steps of the study were citrus juice characteristics, effect of transmembrane pressure and cross flow velocity on the permeate flux, rejection, quality of citrus juice, and mass transfer mechanism on the microfiltration of citrus juice according to the total recycle operation mode. Mass transfer mechanism was analyzed by comparing the experimental data with calculation data using thin film models of non-Newtonian fluids based on non-dimensional analysis with Brownian diffusion and shearinduced diffusion approach, Zidney-Colton model, and Davis-Sherwood model. The results showed the fresh citrus juice is a non-Newtonian fluid and a character of dilatant. The limiting flux reached at the transmembrane pressure of 1.84 bar. Optimum condition for microfiltration citrus juice at the transmembrane pressure of 1.74 bar and flow rate of 0.08 ms-1 for 30 minutes, with the permeate flux about 63.16 L m-2h-1. In these conditions, the microfiltration of citrus juice could remove limonin and naringin, respectively by 92.54 % and 71.34 %. The limonin rejection was higher than naringin because limonin is more hydrophobic so that adsorbed onto membrane surface easier. High transmembrane pressure application caused decreasing vitamin C and total soluble solids content in the permeate, respectively by 44.48 % and 38.18 %. Mass transfer mechanisms on the microfiltration of citrus juice strongly depend on citrus juice properties. Presence of particles in citrus juice caused increasing of shear rate on membrane wall, so that increase particle deposition rates from membrane surface. Mass transfer mechanisms on the microfiltration of citrus juice were affected by particle size, particle concentration, and shear rate as showed by close value of experimental data with Zidney-Colton model. Finally, the mass transfer mechanism on the microfiltration Siam citrus juice for removing limonin and naringin could be decribed as mass transfer mechanism by shear-induce diffusion and fresh citrus juice is a dilute suspension.